Preview

Oil and Gas Studies

Advanced search

Study of phase evolution and microstructural features when modeling operating conditions of fuel cells based on lanthanum-strontium ferrite compounds

https://doi.org/10.31660/0445-0108-2024-3-135-147

Abstract

   Interest in lanthanum-strontium ferrite ceramics having mixed electron and oxygen-ion conductivity as well as good stability is due to the great potential for use as electrode materials for solid oxide fuel cells. The article presents the results of an assessment of alterations in the morphology and phase composition of ceramics based on lanthanum-strontium ferrite compounds obtained by solid-phase synthesis. This was done during simulation of conditions as close as possible to their operating conditions in the mode of elevated temperatures. The primary objective of the research is to alter the
ratio of the phase composition of ceramics under prolonged thermal exposure, simulating thermal ageing processes, and thus, oxidation processes that occur during long-term cyclic tests. The studies revealed that the presence of the Sr2Fe2O5 phase in the composition of ceramics results in enhanced resistance to corrosive oxidation processes during high-temperature corrosion. The data obtained on the change in the electrochemical characteristics of ceramics depending on the exposure time during the simulation of high-temperature degradation revealed that the most significant decreases were observed after 400-500 hours of consecutive tests at a temperature of 500-600 °C and after 250-300 hours at temperatures above 700 °C. Moreover, the reduction in the specific power is due to the formation of oxide inclusions in ceramics, resulting from the decomposition of the (La0.3Sr0.7)FeO4 phase in the composition of the ceramics. In turn, the presence of the Sr2Fe2O5 phase results in the formation of an oxidation-resistant structure, leading to less pronounced changes in specific power during measurement of parameters of electrochemical characteristics.

About the Authors

D. B. Borgekov
L.N. Gumilyov Eurasian National University
Kazakhstan

Daryn B. Borgekov, PhD, Researcher

Astana



K. B. Kaliyekperova
L.N. Gumilyov Eurasian National University
Kazakhstan

Kamila B. Kaliyekperova, PhD Doctoral Student

Astana



A. L. Kozlovskiy
L.N. Gumilyov Eurasian National University; Atyrau University named after Kh. Dosmukhamedov
Kazakhstan

Artem L. Kozlovskiy, PhD, Teacher-Researcher

Astana; Atyrau



G. Zh. Moldabayeva
Satbayev University
Kazakhstan

Gulnaz Zh. Moldabayeva, Doctor of Engineering, Professor

Department of Petroleum Engineering

Almaty



References

1. Jose, J. K., & Balakrishnan, R. (2023). Multiferroics for Spintronic Applications. Nanotechnology in Electronics: Materials, Properties, Devices, pp. 301-316. (In English). DOI: 10.1002/9783527824229.ch10

2. Aguadero, A., De La Calle, C., Pérez‐Coll, D., & Alonso, J. A. (2011). Study of the crystal structure, thermal stability and conductivity of Sr ((V0.5Mo0.5) O3+δ as SOFC material. Fuel Cells, 11(1), pp. 44-50. (In English). DOI: 10.1002/fuce.201000070

3. Weber, A., & Ivers-Tiffée, E. (2004). Materials and concepts for solid oxide fuel cells (SOFCs) in stationary and mobile applications. Journal of power sources, 127(1-2), рр. 273-283. (In English). DOI: 10.1016/j.jpowsour.2003.09.024

4. Das, T., Nicholas, J. D., & Qi, Y. (2017). Polaron size and shape effects on oxygen vacancy interactions in lanthanum strontium ferrite. Journal of Materials Chemistry A, 5(47). (In English). Available at: doi: 10.1039/c7ta06948k

5. Qin, C., Liu, R., Sun, Y., Wu, J., Zhao, T., & Gong, H. (2023). Phase formation and magnetic properties of M-type lanthanum substituted strontium ferrites. Ceramics International, 49(19). (In English). doi: 10.1016/j.ceramint.2023.07.171

6. Ramona, T., Martin, G., Marc, H., Bernhard, K., & Simon, P. (2015). Exsolution of Fe and SrO Nanorods and Nanoparticles from Lanthanum Strontium Ferrite La0.6Sr0.4FeO3−δ Materials by Hydrogen Reduction. The Journal of Physical Chemistry C, 119(38). (In English). doi: 10.1021/acs.jpcc.5b06014.

7. Das, T., Nicholas, J. D., & Qi, Y. (2020). Composition, crystallography, and oxygen vacancy ordering impacts on the oxygen ion conductivity of lanthanum strontium ferrite. Physical Chemistry Chemical Physics, 22(17). (In English). doi: 10.1039/d0cp00206b

8. Chavan, S. V., & Singh, R. N. (2013). Preparation, properties, and reactivity of lanthanum strontium ferrite as an intermediate temperature SOFC cathode. Journal of Materials Science, 48. (In English). Available at: doi: 10.1007/s10853-013-7456-9

9. Paiva, J. A. E., Daza, P. C. C., Rodrigues, F. A., Ortiz-Mosquera, J. F., da Silva, C. R. M., Munoz, M. M., & Meneses, R. A. M. (2020). Synthesis and electrical properties of strontium-doped lanthanum ferrite with perovskite-type structure. Ceramics International, 46(11). (In English). doi: 10.1016/j.ceramint.2020.04.212

10. Kim, M., Kim, D. H., Han, G. D., Choi, H. J., Choi, H. R., & Shim, J. H. (2020). Lanthanum strontium cobaltite-infiltrated lanthanum strontium cobalt ferrite cathodes fabricated by inkjet printing for high-performance solid oxide fuel cells. Journal of Alloys and Compounds, 843. (In English). doi: 10.1016/j.jallcom.2020.155806

11. Gross, M. D., Vohs, J. M., & Gorte, R. J. (2007). A study of thermal stability and methane tolerance of Cu-based SOFC anodes with electrodeposited Co. Electrochimica Acta, 52(5). (In English). doi: 10.1016/j.electacta.2006.08.005

12. Lu, F., Yang, M., Shi, Y., Wu, C., Jia, X., He, H.,… Cai, B. (2021). Application of a negative thermal expansion oxide in SOFC cathode. Ceramics International, 47(1), pp. 1095-1100. (In English). DOI: 10.1016/j.ceramint.2020.08.225

13. Chen, H., Lucas, J. A., Priyantha, W., Kopczyk, M., Smith, R. J., Lund, K.,... Nachimuthu, P. (2008). Thermal stability and oxidation resistance of TiCrAlYO coatings on SS430 for solid oxide fuel cell interconnect applications. Surface and Coatings Technology, 202(19). (In English). doi: 10.1016/j.surfcoat.2008.04.059

14. Garai, M., Singh, S. P., & Karmakar, B. (2021). Mica (KMg<sub>3</sub>AlSi<sub>3</sub>O<sub>10</sub>F<sub>2</sub>) based glass-ceramic composite sealant with thermal stability for SOFC application. International Journal of Hydrogen Energy, 46(45). (In English). doi: 10.1016/j.ijhydene.2020.10.252

15. Borgekov, D. B., Kozlovskiy, A. L., Shakirzyanov, R. I., Zhumazhanova, A. T., Zdorovets, M. V., & Shlimas, D. I. (2022). Properties of Perovskite-like Lanthanum Strontium Ferrite Ceramics with Variation in Lanthanum Concentration. Crystals, 12(12). (In English). doi 10.3390/cryst12121792


Review

For citations:


Borgekov D.B., Kaliyekperova K.B., Kozlovskiy A.L., Moldabayeva G.Zh. Study of phase evolution and microstructural features when modeling operating conditions of fuel cells based on lanthanum-strontium ferrite compounds. Oil and Gas Studies. 2024;(3):135-147. (In Russ.) https://doi.org/10.31660/0445-0108-2024-3-135-147

Views: 169


ISSN 0445-0108 (Print)