Problems in diagnostics and forecasting for the resource of wire ropes in drilling rigs
https://doi.org/10.31660/0445-0108-2020-4-100-109
Abstract
Continuous monitoring of the rig's technical condition is necessary for efficient use of the rig's wire rope resource. A classification of steel ropes used in the industry has been compiled. The characteristics of the pulley-block rope pulley to power drilling rigs are given. The analysis of recommendations for the selection and operation of rope hoists is carried out. The reasons for the occurrence of complex stress-strain states of the rope during its operation are considered. The analysis of methods for calculating the load-bearing capacity of wire rope and determining the fatigue strength is given. Comparative data on the actual standard operating time of wire rope are given. The scientific problem of predicting the residual resource of wire rope is analytically investigated. For operational control of defects in steel ropes, the prospects of using magnetic flaw detection methods are considered. The article draws our attention to the need to implement the following scientific, technical, and technological solutions, such as improving the design of pulley-block system of drilling rigs; accuracy increase of diagnosis of technical condition and forecasting of resource strings; maintenance of wire rope; this will contribute to a more complete use of wire rope in drilling rig.
About the Authors
V. V. Piven
Industrial University of Tyumen
Russian Federation
Russian Federation
Valeriy V. Piven, Doctor of Engineering, Professor at the Department of Machinery and Equipment of the Oil and Gas Industry
Tyumen
E. Yu. Moskvina
Industrial University of Tyumen
Russian Federation
Russian Federation
Elena Yu. Moskvina, Candidate of Engineering, Associate Professor at the Department of Machinery and Equipment of the Oil and Gas Industry
Tyumen
V. V. Pivdiablyk
Industrial University of Tyumen
Russian Federation
Russian Federation
Vladimir V. Pivdiablyk, Master's Student at the Department of Machinery and Equipment of the Oil and Gas Industry
Tyumen
References
1. Malinovskiy, V. A. (2016). Stal'nye kanaty: analiticheskiy spravochnik. Odessa, Astroprint Publ., 252 p. (In Russian).
2. Sungurov, E. V. (2015). Podgotovka k prognozirovaniyu resursa stal'nykh kanatov kar'ernykh ekskavatorov. Rossiya molodaya: sbornik materialov VII Vserossiyskoy nauchnoprakticheskoy konferentsii molodykh uchenykh s mezhdunarodnym uchastiem. Kemerovo, T. F. Gorbachev Kuzbass State Technical University Publ., pp. 138-141. (In Russian).
3. Ilinyh A., Alekseev D., & Gareys A. (2007). Analysis of the steel ropes using in "Uralmash - Drilling equipment" drilling rigs. Burenie i neft', (6), pp. 34-37. (In Russian).
4. Slesarev, D. A., Potekhin, O. P., Shpakov, I. I., Volokhovsky, V. Yu., & Vorontsov, A. N. (2018). Monitoring of Technical Condition of the Wire Ropes of Drilling Rigs for Production and Exploratory Drilling of Oil and Gas Wells: Technology, Efficiency, Prospects. Occupasional Safety in Industry, (6), pp. 13-22. (In Russian). DOI: 10.24000/0409-2961-2018-6-13-22
5. Efimchenko, S. I. (2001). Raschety resursa nesushchikh elementov burovykh ustanovok. Moscow, Gubkin University Publ., 171 p. (In Russian).
6. Vorobel, S. V. Trifanov, G. D., & Ostrovsky, V. G. (2019). Determination of the drill rope specific work. Construction of Oil and Gas Wells on Land and Sea, (5), рр. 44-48. (In Russian). DOI: 10.30713/0130-3872-2019-5-44-48
7. Vorontsov, A. N., & Volokhovsky, V. Yu. (2012). Mechanical model for strength and life-time assessment of tested hoisting ropes. Handbook. An Engineering Journal with appendix, (10(187)), pp. 37-43. (In Russian).
8. Dubuisson, J., & Cantin, M. (2007). Study on mechanical conditions of looseness of outer wires of ropeway haulage ropes. OIPEEC Conference, Johannesburg, pp. 175-193. (In English).
9. Vorontsov, А. N., Volokhоvskii, V. Ju., & Sukhorukov, V. V. (2014). Residual life assessment of wire rope on the results of magnetic testing. Aktual'nye problemy povysheniya effektivnosti i bezopasnosti ekspluatatsii gorno-shakhtnogo i neftepromyslovogo oborudovaniya, 1(1), pp. 33-40. (In Russian).
10. Sukhorukov, V. (2019). Tecnical Diagnostics of Steel Ropes in Extractive Industry: from Flaw Detection to Automated Monitoring. NDT World, 22, pp. 4-8. (In Russian). DOI: 0.12737/article_5d5fcca11f3624.52556014
11. Sukhorukov, V. (2001). Steel wire ropes NDT: new instruments. Proceedings of the 6th International Conference of the Slovenian Society for Non-destructive Testing. Portoro, pp. 225-230. (In English).
12. Vorontsov, A., Volokhovsky, V., & Slesarev, D. (2011). Combined approach to damaged wire ropes life-time assessment based on NDT results and rope mechanics. Journal of Physics: Conference series, 305, pp. 1-9. (In English). DOI: 10.1088/1742-6596/305/1/012114
13. Sukhorukov, V. V., Slesarev, D. A., & Vorontsov, A. N. (2014). Electromagnetic inspection and diagnostics of steel ropes: technology, effectiveness and problems. Materials Evaluation, 72(8), pp. 1019-1027 (In English).
14. Slesarev, D., Sukhorukov, D., & Shpakov, I. (2017). Automated magnetic rope condition monitoring: concept and practical experience. Proceedings of the OIPEEC Conference. La Rochelle, pp. 295-300. (In English).
15. Sukhorukov, V., Mironenko, A., Perepelitsyn, A., & Saplin, A. (2003). Monitoring of Mine Hoist Ropes at the Norilsk Nikel Company. Proceedings of the International Conference "Mining Transport" (Szczyrk, Poland, September, 24-26, 2003). pp. 111-118. (In English).
16. Potekhin, O. P., Shpakov, I. I. (2016). Monitoring hoist ropes technical condition with the use of magnetic flaw detectors as a means of safe operation of drilling rigs. Burenie i neft', (1), pp. 52-59. (In Russian).
17. Gronau, O., Belitsky, S., & Sukhorukov, V. (2000). NDT of Steel Ropes with Magnetic Flaw Detectors: Documentation and Interpretation of Test Results. Proceedings of the 15th WCNDT (October, 16-21). Rome. (In English).
18. Marias, J. (2011). Holistic Approach to Continuous Rope Monitoring. OIPEEC Conference Proceedings (Texas, USA, March, 2011). (In English).
Review
For citations:
Piven V.V., Moskvina E.Yu., Pivdiablyk V.V. Problems in diagnostics and forecasting for the resource of wire ropes in drilling rigs. Oil and Gas Studies. 2020;(4):100-109. (In Russ.) https://doi.org/10.31660/0445-0108-2020-4-100-109
Views:
459
Email this article 
Post a Comment 